E36 318is - Fuel pump issue?
I think my fuel pump is knackered. Car is currently issue free and everything is perfect or at least I thought. I think there is something in the water as my mams fuel pump went there about a week ago + member here. Lucky it's fixed as I'm back driving her car haha.
I went to drive to work today car started fine. Hadn't drove it yesterday. Drove about 1/2 mile. Was really rough so I pulled in at the end of our road before I drove out on the main road. Stopped car conked blocking the road. Started would only run for about 5 to 10 secounds revs hunting between 500-2000rpm. Started every time and conked after about 5 secs every time. I managed to do a 3 point turn revving the life out of it and got it turned for home. I drove it back in the road in 1st gear keeping revs high and it made it home.
How can I check if it's the fuel pump? I can tow it/trailer it to mechanic if needed but it would be a lot of hassle as I live in the sticks. I was thinking about buying a secound hand fuel pump off ebay €40delivered and if this fixes it to buy a new one?
Leading me to my next question what models are the same pumps in as I have access to a few E36 scrappers non of which are M44 unfortunately though.
Car is approaching championship mileage at 187k and covery 90 miles every day for reference.
E36 318is - Fuel pump issue?
Are you getting ignition spark to the plugs? Had a familer sounding problem on my m44 an was a sensor under the intake manifold. Had melted to bare wire an was shorting off itself.
I hope this May be the case as it's a cheaper fix than the fuel pump.
Sent from my iPhone using Tapatalk
RE: E36 318is - Fuel pump issue?
Dissappointing response - any feedback is welcomed
RE: E36 318is - Fuel pump issue?
the way i tested mine was
lift back seat turn on ignition listen for noise you may need to try start it to get the pump to make a noise
next get in the back and check if its getting power with a multimeter
and lastly i took the engine cover off and theres a small valve like a tyre valve on the fuel rail stick a pin in the valve and check for pressure (it should be strong) if it dribbles out the pump is gone {not sure if m44 is in the same location}
you symptoms are slightly similar to mine but the reason i didn't post earlier is because i couldn't get the car to run but you can so maybe your is just about to fail
when was the last time you changed the fuel filter
id start by trying what i siad above anyways at least you can eliminate then
RE: E36 318is - Fuel pump issue?
Cheers for the reply sir.
I changed the fuel filter last year around September.
I'll have a look at in the morning but its just so weird that it did this so suddenly. Probably about time for it to fail but not the end of the world.
RE: E36 318is - Fuel pump issue?
the one in the e46 just died without warning i was suprised for it to dye like that but there you go
E36 318is - Fuel pump issue?
In a dramatic change of events it's 100% this morning! Dodgey petrol?
Sent forward in time from my Nokia 3210
RE: E36 318is - Fuel pump issue?
Replied to your post on driver there, and just saw it here then. Also check all electrical connections to the pump and with the car running wriggle them about to see does it stir anything up.
RE: E36 318is - Fuel pump issue?
Will drive it to work today. If I feel it isn't working properly or don't have confidence in it I have one sourced secound hand to try and like I said if that works will put in a new one. Gonna bring if for a spin shortly. It ran there for 20 mins no problem but haven't actually drove it anywhere yet!
RE: E36 318is - Fuel pump issue?
I had a similar problem with mine (Wouldn't tick over and would just die with a backfire, Fine if the revs were kept up though)
I just cleaned the Idle Control Valve and it sorted it. :)
E36 318is - Fuel pump issue?
Brought it for a spin there tried it on the hills out our own road will pull up the hills in first no problem no throttle. Spirited spin then no problems al all. Must have just been dirty petrol or maybe something is about to die. Pump doesn't sound weak or weird either sounds normal enough.
Sent forward in time from my Nokia 3210
E36 318is - Fuel pump issue?
So I swapped the fuel pump rely for a spare I had. I also checked the filler cap and the rubber seemed a bit dry not perished though. Seems to be loosing its shape. I put some silicone lubricant on it. Would this seal be enough to cause my symptoms?
Sent forward in time from my Nokia 3210
E36 318is - Fuel pump issue?
Quote:
Originally Posted by BMW
I had a similar problem with mine (Wouldn't tick over and would just die with a backfire, Fine if the revs were kept up though)
I just cleaned the Idle Control Valve and it sorted it. :)
Depressing and all as it is this is still happening. Car started normally drove 1 mile car stalled at a junction and would start run for 10 secs and them die.
What does the idle control valve look like in M44 is it the black circle round thing?
Sent forward in time from my Nokia 3210
E36 318is - Fuel pump issue?
How do I know if it's the cam sensor that is faulty?
Sent forward in time from my Nokia 3210
Re: E36 318is - Fuel pump issue?
Idle control valve wouldn't cause an issue like this
You need to get a diagnosis done its the only way forward
E36 318is - Fuel pump issue?
Ya a few people have suggested it but afaik mine is new I changed it myself. It's a black circle about 1cm high with two bolts that come out with an Allen key.
Just reading some old posts and they seem to be suggesting cam sensor?
Sent forward in time from my Nokia 3210
[hr]
Quote:
Originally Posted by Gar
You need to get a diagnosis done its the only way forward
Will be visiting Rob tomorrow!
Sent forward in time from my Nokia 3210
Re: E36 318is - Fuel pump issue?
From past posts cam sensor is sounding like a likely culprit
Im not sure if a sensor like that can be diagnosed without using the computer
Keep us posted on what the diagnostic reveals tomorrow
E36 318is - Fuel pump issue?
Didn't even bother checking codes in the end screamed cam sensor which is now replaced. All back to normal €38 later lol
Sent forward in time from my Nokia 3210
Re: E36 318is - Fuel pump issue?
Happy days cheap fix :cool:
RE: E36 318is - Fuel pump issue?
That means my diagnoses was correct ;)
RE: E36 318is - Fuel pump issue?
Shane it was that conld've given you one for cheaper